WOOD DUST

PHYSICAL DESCRIPTION: Tan fibrous powder. (NTP, 1992)

none

This chemical may present a strong to severe explosion hazard if dust cloud contact an ignition source. (NTP, 1992). Insoluble in water.

Flash point data for this chemical are not available; however, it is probably combustible. This chemical may present a strong to severe explosion hazard if dust cloud contact an ignition source. (NTP, 1992)

Excerpt from NIOSH Pocket Guide for Wood dust:

Exposure Routes: Inhalation, skin and/or eye contact

Symptoms: Irritation eyes; epistaxis (nosebleed); dermatitis; respiratory hypersensitivity; granulomatous pneumonitis; asthma, cough, wheezing, sinusitis; prolonged colds; [potential occupational carcinogen]

Target Organs: Eyes, skin, respiratory system

Cancer Site: Nasal cancer (NIOSH, 2023)

Incompatible with strong oxidizing agents and drying oils (NTP, 1992).

• Not Chemically Reactive

No information available.

No information available.

Fires involving this material can be controlled with a dry chemical, carbon dioxide or Halon extinguisher. Fires can also be controlled with water and sand. (NTP, 1992)

SMALL SPILLS AND LEAKAGE: If you spill this chemical, you should dampen the solid spill material with water, then transfer the dampened material to a suitable container. Use absorbent paper dampened with water to pick up any remaining material. Seal your contaminated clothing and the absorbent paper in a vapor-tight plastic bag for eventual disposal. Wash all contaminated surfaces with a soap and water solution. Do not reenter the contaminated area until the Safety Officer (or other responsible person) has verified that the area has been properly cleaned.

STORAGE PRECAUTIONS: You should store this material under ambient temperatures. (NTP, 1992)

Excerpt from NIOSH Pocket Guide for Wood dust:

Skin: No recommendation is made specifying the need for personal protective equipment for the body.

Eyes: No recommendation is made specifying the need for eye protection.

Wash skin: No recommendation is made specifying the need for washing the substance from the skin (either immediately or at the end of the work shift).

Remove: No recommendation is made specifying the need for removing clothing that becomes wet or contaminated.

Change: No recommendation is made specifying the need for the worker to change clothing after the workshift. (NIOSH, 2023)

No information available.

EYES: First check the victim for contact lenses and remove if present. Flush victim's eyes with water or normal saline solution for 20 to 30 minutes while simultaneously calling a hospital or poison control center. Do not put any ointments, oils, or medication in the victim's eyes without specific instructions from a physician. IMMEDIATELY transport the victim after flushing eyes to a hospital even if no symptoms (such as redness or irritation) develop.

SKIN: IMMEDIATELY flood affected skin with water while removing and isolating all contaminated clothing. Gently wash all affected skin areas thoroughly with soap and water. If symptoms such as redness or irritation develop, IMMEDIATELY call a physician and be prepared to transport the victim to a hospital for treatment.

INHALATION: IMMEDIATELY leave the contaminated area; take deep breaths of fresh air. IMMEDIATELY call a physician and be prepared to transport the victim to a hospital even if no symptoms (such as wheezing, coughing, shortness of breath, or burning in the mouth, throat, or chest) develop. Provide proper respiratory protection to rescuers entering an unknown atmosphere. Whenever possible, Self-Contained Breathing Apparatus (SCBA) should be used; if not available, use a level of protection greater than or equal to that advised under Protective Clothing.

INGESTION: DO NOT INDUCE VOMITING. If the victim is conscious and not convulsing, give 1 or 2 glasses of water to dilute the chemical and IMMEDIATELY call a hospital or poison control center. Be prepared to transport the victim to a hospital if advised by a physician. If the victim is convulsing or unconscious, do not give anything by mouth, ensure that the victim's airway is open and lay the victim on his/her side with the head lower than the body. DO NOT INDUCE VOMITING. IMMEDIATELY transport the victim to a hospital.

OTHER: Since this chemical is a known or suspected carcinogen you should contact a physician for advice regarding the possible long term health effects and potential recommendation for medical monitoring. Recommendations from the physician will depend upon the specific compound, its chemical, physical and toxicity properties, the exposure level, length of exposure, and the route of exposure. (NTP, 1992)

• HARD WOOD DUST
• MAPLE WOOD DUST
• MAPLE WOOD FLOUR
• SANDERDUST
• SAWDUST
• SOFT WOOD DUST
• WESTERN RED CEDAR DUST
• WOOD DUST
• WOOD FLOUR
• WOOD MEAL