PROPYLENE GLYCOL T-BUTYL ETHER

PHYSICAL DESCRIPTION: Clear colorless liquid with an ethereal odor. (NTP, 1992)

• Highly Flammable

Highly flammable. Sensitive to heat and prolonged exposure to air. Water soluble.

This chemical is combustible. (NTP, 1992)

SYMPTOMS: Symptoms of exposure to this compound via inhalation include coughing, shortness of breath, dizziness, drunkenness and collapse. Eye contact causes irritation. Prolonged skin contact may cause irritation.

ACUTE/CHRONIC HAZARDS: This compound may be absorbed through the skin. When heated to decomposition it emits toxic fumes of carbon monoxide, carbon dioxide and unidentified organic compounds in black smoke. (NTP, 1992)

PROPYLENE GLYCOL T-BUTYL ETHER is incompatible with acids, oxidizing agents, oxygen (prolonged contact), water and dehydrating agents. (NTP, 1992).

• Alcohols and Polyols
• Ethers

Use caution: Liquids with this reactive group classification have been known to react with the absorbent listed below.

• Cellulose-Based Absorbents

Excerpt from 128 [Flammable Liquids (Water-Immiscible)]:

IMMEDIATE PRECAUTIONARY MEASURE: Isolate spill or leak area for at least 50 meters (150 feet) in all directions.

LARGE SPILL: Consider initial downwind evacuation for at least 300 meters (1000 feet).

FIRE: If tank, rail car or tank truck is involved in a fire, ISOLATE for 800 meters (1/2 mile) in all directions; also, consider initial evacuation for 800 meters (1/2 mile) in all directions. (ERG, 2020)

Fires involving this material can be controlled with a dry chemical, carbon dioxide or Halon extinguisher. A water spray may also be used. (NTP, 1992)

SMALL SPILLS AND LEAKAGE: If you should spill this chemical, use absorbent paper to pick up all liquid spill material. Seal the absorbent paper, as well as any of your clothing which may be contaminated, in a vapor-tight plastic bag for eventual disposal. Wash any surfaces you may have contaminated with a soap and water solution. Do not reenter the contaminated area until the Safety Officer (or other responsible person) has verified that the area has been properly cleaned.

STORAGE PRECAUTIONS: You should keep this material in a tightly closed container under an inert atmosphere, and store it at refrigerated temperatures. (NTP, 1992)

RECOMMENDED RESPIRATOR: Where the neat test chemical is stored, weighed and diluted, wear an approved half face respirator equipped with an organic vapor/acid gas cartridge (specific for organic vapors, HCl, acid gas and SO2) with a dust/mist filter. (NTP, 1992)

No information available.

EYES: First check the victim for contact lenses and remove if present. Flush victim's eyes with water or normal saline solution for 20 to 30 minutes while simultaneously calling a hospital or poison control center. Do not put any ointments, oils, or medication in the victim's eyes without specific instructions from a physician. IMMEDIATELY transport the victim after flushing eyes to a hospital even if no symptoms (such as redness or irritation) develop.

SKIN: IMMEDIATELY flood affected skin with water while removing and isolating all contaminated clothing. Gently wash all affected skin areas thoroughly with soap and water. If symptoms such as redness or irritation develop, IMMEDIATELY call a physician and be prepared to transport the victim to a hospital for treatment.

INHALATION: IMMEDIATELY leave the contaminated area; take deep breaths of fresh air. If symptoms (such as wheezing, coughing, shortness of breath, or burning in the mouth, throat, or chest) develop, call a physician and be prepared to transport the victim to a hospital. Provide proper respiratory protection to rescuers entering an unknown atmosphere. Whenever possible, Self-Contained Breathing Apparatus (SCBA) should be used; if not available, use a level of protection greater than or equal to that advised under Protective Clothing.

INGESTION: If the victim is conscious and not convulsing, give 1 or 2 glasses of water to dilute the chemical and IMMEDIATELY call a hospital or poison control center. Be prepared to transport the victim to a hospital if advised by a physician. If the victim is convulsing or unconscious, do not give anything by mouth, ensure that the victim's airway is open and lay the victim on his/her side with the head lower than the body. DO NOT INDUCE VOMITING. IMMEDIATELY transport the victim to a hospital. (NTP, 1992)

• 1-(1,1-DIMETHYLETHOXY)-2-PROPANOL
• 1-METHYL-2-TERT-BUTOXYETHANOL
• 2-PROPANOL, 1-(1,1-DIMETHYLETHOXY)-
• PROPYLENE GLYCOL T-BUTYL ETHER
• PROPYLENE GLYCOL TERT-BUTYL ETHER
• 1-T-BUTOXY-2-PROPANOL
• 1-TERT-BUTOXY-2-PROPANOL