BUTYLATED HYDROXYANISOLE

PHYSICAL DESCRIPTION: White, beige or slightly yellow waxy solid with an aromatic odor and a slightly bitter burning taste. (NTP, 1992)

none

Insoluble in water.

This chemical is combustible. (NTP, 1992)

SYMPTOMS: Symptoms of exposure to this compound may include allergic contact dermatitis, exacerbation of vasomotor rhinitis, conjunctival irritation and redness, asthma, facial flushing, marked diaphoresis, headaches, dull retrosternal pain and somnolence. It may also cause hypersensitivity reactions after skin contact.

ACUTE/CHRONIC HAZARDS: This compound is toxic by ingestion. When heated to decomposition this compound emits acrid smoke and irritating fumes. (NTP, 1992)

BUTYLATED HYDROXYANISOLE degrades with prolonged exposure to sunlight. Exhibits antioxidant properties and synergism with acids, BHT, propyl gallate, hydroquinone, methionine, lecithin and thiodipropionic acid. It exhibits antioxidant properties as a scavenger of free radicals. It is incompatible with oxidizing agents and ferric salts. (NTP, 1992)

• Ethers
• Phenols and Cresols

No information available.

No information available.

Fires involving this compound can be controlled with a dry chemical, carbon dioxide or Halon extinguisher. (NTP, 1992)

SMALL SPILLS AND LEAKAGE: Should a spill occur while you are handling this chemical, FIRST REMOVE ALL SOURCES OF IGNITION, then you should dampen the solid spill material with 60-70% ethanol and transfer the dampened material to a suitable container. Use absorbent paper dampened with 60-70% ethanol to pick up any remaining material. Seal the absorbent paper, and any of your clothes, which may be contaminated, in a vapor-tight plastic bag for eventual disposal. Solvent wash all contaminated surfaces with 60-70% ethanol followed by washing with a soap and water solution. Do not reenter the contaminated area until the Safety Officer (or other responsible person) has verified that the area has been properly cleaned.

STORAGE PRECAUTIONS: You should protect this material from exposure to light. Keep it away from oxidizing materials and store it at ambient temperatures. (NTP, 1992)

MINIMUM PROTECTIVE CLOTHING: If Tyvek-type disposable protective clothing is not worn during handling of this chemical, wear disposable Tyvek-type sleeves taped to your gloves.

RECOMMENDED RESPIRATOR: Where the neat test chemical is weighed and diluted, wear a NIOSH-approved half face respirator equipped with a combination filter cartridge, i.e. organic vapor/acid gas/HEPA (specific for organic vapors, HCl, acid gas, SO2 and a high efficiency particulate filter). (NTP, 1992)

No information available.

EYES: First check the victim for contact lenses and remove if present. Flush victim's eyes with water or normal saline solution for 20 to 30 minutes while simultaneously calling a hospital or poison control center. Do not put any ointments, oils, or medication in the victim's eyes without specific instructions from a physician. IMMEDIATELY transport the victim after flushing eyes to a hospital even if no symptoms (such as redness or irritation) develop.

SKIN: IMMEDIATELY flood affected skin with water while removing and isolating all contaminated clothing. Gently wash all affected skin areas thoroughly with soap and water. IMMEDIATELY call a hospital or poison control center even if no symptoms (such as redness or irritation) develop. IMMEDIATELY transport the victim to a hospital for treatment after washing the affected areas.

INHALATION: IMMEDIATELY leave the contaminated area; take deep breaths of fresh air. IMMEDIATELY call a physician and be prepared to transport the victim to a hospital even if no symptoms (such as wheezing, coughing, shortness of breath, or burning in the mouth, throat, or chest) develop. Provide proper respiratory protection to rescuers entering an unknown atmosphere. Whenever possible, Self-Contained Breathing Apparatus (SCBA) should be used; if not available, use a level of protection greater than or equal to that advised under Protective Clothing.

INGESTION: DO NOT INDUCE VOMITING. If the victim is conscious and not convulsing, give 1 or 2 glasses of water to dilute the chemical and IMMEDIATELY call a hospital or poison control center. Be prepared to transport the victim to a hospital if advised by a physician. If the victim is convulsing or unconscious, do not give anything by mouth, ensure that the victim's airway is open and lay the victim on his/her side with the head lower than the body. DO NOT INDUCE VOMITING. IMMEDIATELY transport the victim to a hospital.

OTHER: Since this chemical is a known or suspected carcinogen you should contact a physician for advice regarding the possible long term health effects and potential recommendation for medical monitoring. Recommendations from the physician will depend upon the specific compound, its chemical, physical and toxicity properties, the exposure level, length of exposure, and the route of exposure. (NTP, 1992)

• ANTIOXYNE B
• ANTRANCINE 12
• BHA
• BHA (ANTIOXIDANT)
• BOA
• BOA (ANTIOXIDANT)
• BUTYLATED HYDROXYANISOLE
• BUTYLHYDROXYANISOLE
• (1,1-DIMETHYLETHYL)-4-METHOXYPHENOL
• EEC NO. E320
• EMBANOX
• NIPANTIOX 1-F
• PHENOL, TERT-BUTYL-4-METHOXY-
• PREMERGE PLUS
• PROTEX
• SUSTAN 1-F
• SUSTANE
• SUSTANE 1-F
• SUSTANE 1F
• TENOX BHA
• TERT-BUTYL-4-HYDROXYANISOLE
• 2(3)-TERT-BUTYL-4-HYDROXYANISOLE
• TERT-BUTYL-4-METHOXYPHENOL
• 2-TERT-BUTYL-4-METHOXYPHENOL
• TERT-BUTYL-P-HYDROXYANISOLE
• TERT-BUTYLHYDROXYANISOLE
• VERTAC